Horse Rugs - Which rug for your conditions?

Wet weather or cool nights? To rug or not to rug? This  guide will help you make those decisions to insure your horses comfort and good health. A guide to horse rugs and common terminology.

When To Rug?

When in doubt, you're usually better going lighter than heavier, because overheating tends to be the greater danger for horses. You can do this quick check:

• Your horse is probably too cold if he's shivering, seems unusually tense or stiff, has cold ears, or has hairs standing on end.
• Your horse is probably too warm in his rug if he's sweating (check the rib cage, not just the shoulder) or seems unusually restless
  

When  & Why should I rug my horse?
The answer to this question will be different for each horse. Consider the factors below when assessing your horses needs.

Your Horses Coat - Most horses will grow a thick winter coat if left unrugged.  Cold weather causes your horse's hairs to stand on end, which creates an insulating effect with warm air trapped near the skin. Putting a rug on a hairy horse can reduce that insulating power by flattening the hairs. (And actually make him colder!)

However, if your horse's winter coat is thin or if you want a short coat for showing then a rug is  necessary to make up for what's missing and prevent a thick coat from growing (for showing)
 
Weather-  Horses with full winter coats can stay warm, without rugs, in temperatures well below zero.  However  it is  important to consider other weather factors, such as humidity, wind chill, and rain.

When soaked, even a thick winter coat can lose its warming power, leaving your horse chilled to the skin. Similarly, stiff winds can lift the hair coat, allowing icy blasts to penetrate straight to the horse's skin. So, a horse that might be comfortable naked on a dry 20-degree day might appreciate a lightweight, waterproof cover if it's windy or wet, even at a more moderate temperature.

Remember  that the notions of "warm" and "cool" are relative.  A SE Qld  horse accustomed to winter day temperatures around 19 c  will likely find 13 c degrees chilly if he's suddenly relocated to a southern state. That horse might need a rug even when his stable mates, accustomed to the local weather, might not.

Age and health- Foals and older  horses have a harder  time keeping themselves warm than an animal in his prime, so a rug might boost their comfort levels and help them stay healthy. Likewise, an ill horse will benefit from an extra coat while his immune defences are low.

What type of rug should I use to keep my horse Warm or Cool ?

This really depends on the season. With  such variations from season to season, and even day to night time temperatures in Australia, you will need to have a variety of rugs to insure your horse is comfortable.

In the summer months, in  the hotter states,  many people opt for a cool fly mesh rug. Made from fine, yet strong, mesh it helps to  keep annoying fly’s off you horse and allows the breeze to pass thru the rug.  They  should have a UV rating to lessen the harsh Australian sun. They are durable and versatile and are an ideal solution in Summer.

Also very popular are the cotton/polyester Ripstop rugs. These are light weight and cool, they keep the sun off your horse – and  will prevent your horse's coat from fading, and assit to keep it clean, which is important for showing.  They are also light weight and will give your horse some insulation in the cool nights.

For cold or wet weather a turnout rug is most appropriate. Generally the synthetic rugs are most suitable as they are light, 100% waterproof, and dry out easily. The downside is they do need to be removed when the weather clears in the warmer months as your horse can over heat in them once the sun comes out and humidity goes up. Unfortuantly they are yet to invent a waterproof cool rug! Kind of like tring to find a cool raincoat or Drizabone.

Turnout rugs come in both lined and unlined versions.  Many opt for an  unlined turnout rug  and then layer stable/Ripstop  rugs underneath in the cooler weather  to get the desired warmth.
Turnout rugs typically come in three weights :

• Light (no fill) often called an All Seasons turnout
• Medium to Heavy (250-300grams), ideal for Australian Winters
• Extra heavy (Over 300grams).  Extreme Cold

What materials should I look for in a good winter rug, for both the outer shell and fill/lining?

Most turnout rugs have an outer shell of nylon, polyester, or  polypropylene. Stable rugs are often made of cotton, cotton blends, or polar fleece.
The strength (and thus durability) of a rug's outer layer is expressed in terms of its denier (a unit of measurement for fineness); the higher the denier number, the stronger the material. For a horse that is out in the paddock, we recommend  nothing less than 1200 denier for turnouts. You'll also see a selection of linings; polycotton, nylon, and fleece-like wicking material are the most common. Picking one is a matter of personal preference.

When selecting a rug, also consider whether it's waterproof (a must for turnout in wet weather) and breathable.  (Please refer to our other guides for more detailed information on these ratings) Breathable rugs allow moisture near the horse's skin to pass through to the surface. For instance, if your rugged horse works up a sweat romping with his pals on a brisk winter day, a breathable rug will help him stay at a comfortable temperature -and prevent chills- by allowing the sweat to escape into the air.

Common Rug Terminology:

Rip stop
Rip stop refers to the type of material the rugs are made from. Rip stop is a way of modifying the wrap & weft of a fabric to enable it to contain rips & tears. The design insures that a rip or tear will be contained to a smaller area than would otherwise be expected. It will not stop barbed wire tears, but will assist to contain them.

Rug Filling and Material
Rugs are available in different 'weights'. This refers to the amount of filling the rug has to provide insulation. Lightweight rug would be deemed to be suitable for spring, summer and less cold autumn days. A medium to heavy weight rug would be used in late spring thru Winter, maybe over a polar fleece rug or similar depending on your conditions.

Denier
Denier is a measure of the linear density, or weight per unit length, of a yarn-- essentially the higher the denier number the stronger the material commonly in 300D, 600D, 900D and 1200D the higher the number the stronger the material & more intended for outdoor usage.


Rug Types

Combo Rug
Combo Rugs refer to rugs that combine both a neck rug and body rug. The neck rug is permanently attached.

Turnout or Synthetic Rugs – for where protection from the elements is required.
This type of rug should always be clearly marked as being waterproof. Most rugs of this style are made from Nylon or Polyester. Modern coatings  & treatments often allow this type of rug to be breathable as well as providing weather protection. This helps to keep your horse comfortable in changing conditions.

On this basis, for really cold weather, many people like to keep an under rug in reserve in the tack room. This would normally be made from a comfortable warm soft material which will help your horse maintain his body temperature.  Turnouts are also available with linings for added warmth.

Polar Fleece  Day and Cooler Rugs - Multi purpose
This style of rug covers a variety of uses such as travelling to shows and events or for drying off after exercise or being washed. Some people have separate rugs for each use. Travel rugs can be made from a fleece style fabrics. Cooler rugs are often made of a box weave material with holes which help your horse to dry out whilst still keeping warm.

Fly Sheet/Fly Rug
A Fly Sheet or Fly Rug is a lightweight fine mesh rug which offers protection from the harsh sun, allows the breeze to pass thru and  keeps flies and insects away from your horse during the summer. We recommend purchasing a separate fly mask/veil for complete fly protection.

Summer Sheet or Ripstop Sheet Rugs
A summer sheet is generally a cotton or polyester blend  rug that often incorporates ripstop. It’s a general all purpose rug that keeps the sun off your horses coat,  prevents the coat from fading while helping  to keep your horses coat clean and short

Full hooded Combos
A full hooded combo usually refers to a one piece horse combo. It incorporates a standard horse rug with a full hood attached directly to the rug. This is often safer than using separate rugs  and attaching separate hoods.

Under Rugs
Under Rugs and Liners are often cotton or fleece rugs, and  are used under a Turnout rug to provide extra warmth and protection from friction rubbing from the rug.

Rug Liners
Anti-Rub Liners, Shoulder Liners or Anti-Rub Vests are designed to worn underneath a rug to provide protection from friction rubbing. These are made from thin, stretch material and cover the chest, shoulder and withers which are areas prone to friction sores from rug wear.